| Date of spillage | Spillage | Clean up action | Corrective Action |
| 04/01/2024 | 32 litres of paint spilled | Paint mopped up with cloths and put in general on-site waste area. Later burnt. | Notice posted warning workers to be more careful |
| 28/01/2024 | 205 litre drum of solvents knocked over when storekeeper had to move drums to access plastic resin sacks. Lid to drum was not in place. | Hosepipe use to wash spillage into drain that discharges into lagoon. | Notice posted warning workers to be more careful |
| 29/01/2024 | Loss of water – tap left on in men’s residential area. Flooded dormitory. | None required – residents swept water from building. | None |
| 30/03/2023 | Oil from open drum spilled on bare earth next to borehole 1 | None required – oil seeped into ground. | None |
| 03/04/2024 | Oil from drum spilled on bare earth next to borehole 1. Hole in drum. | None required – oil seeped into ground | Waste oil drum patched and now in use |
| 22/06/2024 | Loss of water – tap left on in toilets in upstairs office area. Water leaked into chemical storage area below. Water went into 4 open drums of solvents (half full) and overflowed onto concrete floor. | Hosepipe use to wash spillage into drain that discharges into lagoon | Fixed ceiling |
| 06/07/2024 | Used oil leaked from waste oil drum onto concrete floor around clean water drain in storage area. | Oil brushed into drain and area washed down with hosepipe. | Rusty waste oil drum patched again and now in use |
| 07/07/2024 | Oil drum knocked over and oil spilled on bare earth next to borehole 1 | None required – oil seeped into ground | None |
| 18/07/2024 | 205 litre drum of solvents spilled when knocked over by storekeeper who moved drums to access plastic resin sacks | Hosepipe use to wash spillage into drain that discharges into lagoon | Notice posted warning workers to be more careful |
| 19/07/2024 | 85 litres of paint spilled. Paint covered plastic mouldings stacked on vehicle loading area floor (bare earth). | None. Paint seeped into ground/dried on surface. Ruined components disposed of in off-site waste area. | Notice posted warning workers to be more careful |
| 26/08/2024 | Split bag of polybutylene terephthalate found on shop floor. Half of plastic pellets spilled out. | Workers picked up pellets by hand and replaced in storage bag. Dust remaining brushed out of factory door (by dormitories). | Split in storage bag patched up. Instructions issued not to leave dust from plastic pellets in open area as dust seen blowing around and into office windows. |
| 18/9/2024 | Air conditioning’s hydrochlorofluorocarbon refrigerant (HCFC) leaking from compressor | None – leak is continuing | Awaiting engineer to fix aircon system. |
Spillages record 01.12.2023 – 30.11.2024
by
Tags: